太陽能塔式電站“聚光—吸熱”系統動態仿真及實驗對比最終報告

徐超　余強　徐二樹　王志峰　李鑫

摘 要：該研究以中國MW級的塔式太陽能熱發電站“大漢”為研究對象，對全系統中區別于常規電站部分的“聚光-吸熱”系統進行數學建模與動態仿真，深入研究系統在外界環境擾動下“光-熱”轉換過程中系統各參數的靜態以及動態特性，為實際電站運行提供指導。其主要研究內容和結果如下： 在聚光系統（定日鏡場）的建模與分析方面：利用基于“蒙特卡洛”的光線追跡法建立了“大漢”定日鏡場中心點聚焦和非中心點聚焦的光學數學模型。通過此模型，不僅對腔式吸熱器內表面的太陽入射能流密度的實時變化進行了模擬，而且對于全年典型天（春（秋）分日、夏（冬）至日）吸熱器腔內能流密度分布規律的變化進行了深入分析。通過實驗對比，驗證了所建模型的有效性。在吸熱系統（腔式吸熱器）的建模與分析方面：利用模塊化建模方法，根據質量、能量以及動量守恒定理，建立了吸熱系統的非穩態全工況的熱物理數學動態模型。該模型不僅能夠?qū)η粌?nèi)管中單相流體（水/蒸汽）吸熱過程中各參數的變化進行仿真，而且還能夠?qū)軆?nèi)水工質因吸熱而發生相變過程中的參數變化進行動態仿真。在耦合系統（“聚光-吸熱”系統）的建模與分析方面：基于“STAR-90”仿真平臺上搭建了“聚光-吸熱”耦合系統的仿真模型。在此基礎上，通過對系統輸入條件的改變，研究了系統在外界輸入條件擾動下各參數的動態變化特性，同時對結果進行了詳細的分析。同時，為了驗證所建模型的有效性，基于上述平臺搭建的“聚光-吸熱”系統仿真模型，通過輸入和“大漢”電站實驗過程中相同的初始條件以及操作步驟，對模擬結果和實驗結果進行了對比驗證。結果表明，該論文所建立的模型具有較高的可靠性。

關鍵詞：太陽能熱發電 聚光系統 吸熱系統 仿真

Abstract：Regarding the first MW-level solar tower power plant “DAHAN” as the research object， this report mainly focuses on the modeling and dynamic simulation of the “concentrator-receiver” system， which is distinguished from the conventional coal-fired plants. Based on the developed models， a deep research on the static and dynamic characteristics of main parameters during the “l(fā)ight-heat” conversion under the disturbances of external environment is performed. The purpose of this research is to provide a significant guidance for the practical operation in the future. The main research and achievements are as follows： The aspect refers to the modeling and simulation of the concentrator system： A centre focus and non-centre focus optical model of “DAHAN” heliostat field was developed based on the monte-carlo ray tracing method. Based on this model， the real-time variation law of incident solar flux on the inner sides of the cavity receiver was not only simulated， but also for the solar flux distribution law on the typical days （spring/autumn equinox， summer/winter solstice）. Finally， the validity of this model was proved by the contrastive analysis. The aspect refers to the modeling and simulation of the receiver system： By adopting the modular modeling method， the unsteady-state and full-working conditions mathematic model of the central receiver system was developed based on the mass， energy and momentum conservation law. It can not only apply to the heat-transfer process of single-phase in the absorbing tubes， but also for the simulation of phase change process in the tubes. The aspect refers to the modeling and simulation of the coupled system： The simulation models of the “concentrator-receiver” system were built based on the “STAR-90” simulation platform， and the dynamic characteristics of the coupled system were studied and analyzed in detail under the disturbances of external environment. In order to verify the validity of the developed models， the simulation results of the coupled system were taken to make a comparison with the experimental data of “DAHAN” plant by following the practical operation procedures on the simulation platform. The results show that the models have a relatively high reliability.

Key Words：Concentrating solar power；Concentrator；Receiver；Modeling

閱讀全文鏈接（需實名注冊）：http：//www.nstrs.cn/xiangxiBG.aspx？id=50549&flag=1