生物質炭材料在雙電層電容器中的應用

盧穎莉，傅冠生，楊 斌，喬志軍

(寧波南車新能源科技有限公司，浙江寧波315112)

生物質炭材料在雙電層電容器中的應用

盧穎莉，傅冠生，楊 斌，喬志軍

(寧波南車新能源科技有限公司，浙江寧波315112)

雙電層電容器電極材料一般由炭材料組成，隨著化石能源的日益枯竭和環境污染的逐步惡化，傳統炭材料的生產和應用受到了挑戰。采用綠色環保的生物質作為碳源，制備雙電層電容器電極材料已成為研究熱點之一。介紹了近幾年來生物質炭材料的制備及其在雙電層電容器中的應用進展，綜述了生物質前驅體和制備方法對雙電層電容器電化學性能的影響。

雙電層電容器；生物質炭材料；多孔炭

雙電層電容器 (electrochemical double-layer capacitors, EDLC)是依靠靜電作用力在電極上儲存電荷的一種儲能器件，與傳統依賴于電荷轉移反應的電池不同，EDLC具有高功率密度、長使用壽命、長放置時間、寬使用溫度、高安全性等優點。根據EDLC的儲能機理，其電容是由電極材料的靜電吸附提供，因此具有大比表面積的多孔炭是EDLC最常見的電極材料。多孔炭通常是從石油焦炭或煤衍生而來，但是隨著礦物日益減少以及這些傳統材料的價格不斷上升，人們?cè)絹碓蕉嗟膶⒛抗馔断蛐沦Y源的開發。

生物質具有來源廣、價格低廉、可再生和綠色環保的優點，它作為碳源制備EDLC電極材料已成為儲能領域研究的熱點。目前以生物質為前驅體，采取不同方法制備多孔炭電極材料是主要發展方向。根據不同的制備方法和多孔炭孔道結構，這些生物質基多孔炭被分為四種：活性炭、介孔炭、分級多孔炭和炭氣凝膠。本文綜述了目前生物質基多孔炭用于EDLC電極材料的研究進展。

1 生物質基多孔炭

1.1 活性炭

活性炭是生物質炭材料的主要衍生產品，目前商業化的生物質活性炭(biomass materials-based activated carbons，BMACs)主要是椰殼基活性炭系列，其商業化YP17(Kuraray Chemical Corporation)在6mol/L KOH溶液中的比電容僅為158 F/g[1]，因此開發具有更高電容的生物質活性炭迫在眉睫。近年來，玉米[2]、咖啡豆[3]、甘蔗渣[4]、稻米殼[5]、木頭[6]、竹子[7]、木薯皮[8]等生物質作為炭材料被用于活性炭電極材料。采用這些原材料制備的活性炭比電容均高于椰殼基活性炭，例如馬鈴薯淀粉基活性炭在6mol/L KOH溶液中甚至具有335 F/g的比電容(電流密度50 mA/g)[9]；麥稈基活性炭在1.2mol/L MeEt3NBF4/ AN有機電解液中呈現251.1 F/g(2 mV/s掃速)的比電容[10]。雖然在低掃描速度或低電流密度下，生物質活性炭具有高的比電容，然而生物質活性炭的孔大多數是由微孔構成，例如木頭和竹子的微孔率高達70%以上(孔徑小于2nm)[6-7]。研究表明在高掃描速度或電流密度下，因電解液離子尺度的問題使其遷移內阻變大，不能快速進入微孔，導致比電容明顯下降，ESR增大，電壓下降明顯(IR drop)[11]。因此具有較多微孔結構的生物質活性炭在大電流充放電時，電容特性表現不佳，例如雞羽毛基活性炭的BET比表面積(SSA)和微孔比表面積分別為1 839和1 575 m2/g，其較高的微孔比表面積使其在1 A/g(1mol/L H2SO4電解液)時具有302 F/g的比電容且壓降為0.12 V，然而當電流密度為10 A/g時，比電容為168 A/g且IR降更明顯，其容量保持率為55.6%(從1 A/g到10 A/g)，如圖1[12]所示。

圖1 雞羽毛基活性炭的透射電鏡圖(a)(b)和恒流充放電曲線(c)

1.2 介孔炭

生物質活性炭的高微孔率使之大電流特性不佳，因此介孔炭(孔徑＞2nm)或高中孔率多孔炭成為生物質炭材料的另一重要產品。H.L.Lu等[13]以硅為模板，采用葡萄糖和硼酸為前驅體制備得到孔徑分布在 2～20nm的有序介孔炭(ordered mesoporous carbons,OMCs)，雖然OMC-M-6的SSA僅為868.5 m2/g，但是其具有高達90%的中孔，結果表明OMC-M-6在30%(質量分?jǐn)?shù))KOH電解液中在1 A/g電流密度下表現出202.8 F/g的比電容，在10 A/g下表現出172.5 F/g的比電容，容量保持率為85.1%(從1 A/g到10 A/g)且未出現明顯的壓降。高中孔率多孔炭與介孔炭具有相似的電化學性能，例如稻米殼基多孔炭[14]和花生殼基多孔炭(mesopore percentage＞82%)[15-16]。與BM-ACs相比，生物質介孔炭或高中孔率多孔炭的優異性能更體現在大電流密度下，但是在小電流密度下，其比電容或能量密度偏低。稻米殼ZnCl活化后，具有1 500 m2/g比表面積的兩種多孔炭，具有較低中孔率(85.2%)的多孔炭比較高中孔率(99.0%)的多孔炭擁有更高的比電容、更穩定的循環性能和更高的容量保持率，表明多孔炭的比電容不僅與中孔有關，而且與微孔有關。因?yàn)槲⒖资请姾蓛?chǔ)存的主要場所，中孔是離子傳輸?shù)耐ǖ馈?/p>

1.3 分級多孔炭

具有高微孔的活性炭在小電流密度下?lián)碛懈叩谋入娙荩哂幸欢ㄎ⒖捉Y(jié)構和較高中孔結構的多孔炭在大電流密度下?lián)碛懈叩谋入娙莺腿萘勘３致剩虼硕嗫滋康目讖椒植己侠硇允瞧渥鳛镋DLCs電極材料的必備條件。由于分級多孔炭(hierarchical porous carbons，HPCs)的大孔(＞50nm)結構提供電解液儲存場所，中孔(2～50nm)結構提供離子傳輸通道，而微孔提供離子儲存場所，因此目前分級多孔炭是擁有最合理孔道結構的電極材料。例如淀粉基HPCs[17]，香蕉皮基HPCs[18]，動物骨頭基HPCs[19]和魚鱗基HPCs[20]。淀粉基HPCs的球形結構、分級的孔道結構(相互連通的大-中-微孔結構)、超高的SSA(3 251 mm2/g)和高中孔率(＞75%)使其在6mol/L KOH溶液中表現出良好的電化學性能，0.05 A/g時比電容為304 F/g，180 A/g時比電容為197 F/g，且10 000次循環后仍能保持98%，如圖2[21]所示。

1.4 炭氣凝膠

生物質材料可以通過溶膠-凝膠、超臨界干燥、冷凍干燥、水熱等方法合成生物質基水凝膠或炭氣凝膠 (hydrogels or aerogels)，例如 β-葡聚糖[22-23]、木質纖維素[24-25]、西瓜[26]、纖維素[27]、甲殼素[28-29]、淀粉[30]等。這些炭氣凝膠具有豐富的大-中孔結構和優越的導電網絡，因此是EDLCs電極材料的重要選擇之一。西瓜基炭氣凝膠及其電化學性能如圖3[26]所示。

圖2 淀粉基HPCs的表觀形貌(a～e)、倍率性能(f)和循環性能(g)

圖3 西瓜基炭氣凝膠及其電化學性能

2 結論

生物質炭材料作為前驅體被廣泛應用于生產活性炭、介孔炭、分級的多孔炭、水凝膠或炭氣凝膠等，減少了化石燃料帶來的環境污染。除此之外，生物質炭材料來源廣泛、價格低廉且具有可再生的特點，因此可作為合成電化學電容器電極材料的重要原材料。然而，就目前生物質炭材料做前驅體而言仍然存在兩個主要問題：(1)灰分較高，前期處理比較繁瑣，例如動物骨頭(灰分33%～43%)[19]和魚鱗(灰分46%)[30]；(2)含炭量或有機炭含量偏低，產率較低，例如杏仁殼(殘?zhí)?5%，多孔炭產率17%)[31]和甘蔗渣(殘?zhí)?9.5%，多孔炭產率34.8%)[4]。因此，尋找一種具有低灰分和高含炭量的生物質炭材料是拓展其應用的重要課題。

[1]HUANG W T,ZHANG H,HUANG Y Q,et al.Hierarchical porous carbon obtained from animal bone and evaluation in electric double-layer capacitors[J].Carbon,2011,49:838-843.

[2]BALATHANIGAIMANI M S,SHIM W G,LEE M J,et al.Highly porous electrodes from novel corn grains-based activated carbons for electrical double layer capacitors[J].Electrochemistry Communications,2008,10:868-871.

[3]THOMAS E R,HULICOVA-JURCAKOVA D,ZHU Z H,et al.Nanoporous carbon electrode from waste coffee beans for high performance supercapacitors[J].Electrochemistry Communications, 2008,10:1594-1597.

[4]THOMAS E R,HULICOVA-JURCAKOVA D,KHOSLA K,et al.Microstructure and electrochemical double-layer capacitance of carbon electrodes prepared by zinc chloride activation of sugar cane bagasse[J].Journal of Power Sources,2010,195:912-918.

[5]GUO Y P,QI J R,JIANG Y Q,et al.Performance of electrical double layer capacitors with porous carbons derived from rice husk [J].Materials Chemistry and Physics,2003,80:704-709.

[6]WU F C,TSENG R L,HU C C,et al.Physical and electrochemical characterization of activated carbons prepared from firwoods for supercapacitors[J].Journal of Power Sources,2004,138:351-359.

[7]KIM Y J,LEE B J,SUEZAKI H,et al.Preparation and characterization of bamboo-based activated carbons as electrode materialsfor electric double layer capacitors[J].Carbon,2006,44:1581-1616.

[8]ISMANTO A E,WANG S T,SOETAREDJO F E,et al.Preparation of capacitor's electrode from cassava peel waste[J].Bioresource Technology,2010,101:3534-3540.

[9]ZHAO S,WANG C Y,CHEN M M,et al.Potato starch-based activated carbon spheres as electrode material for electrochemical capacitor[J].Journal of Physics and Chemistry of Solids,2009,70(9): 1256-1260.

[10]LI X,HAN C,CHEN X,et al.Preparation and performance of straw based activated carbon for supercapacitor in non-aqueous electrolytes[J].Microporous and Mesoporous Materials,2010, 131(1):303-309.

[11]LU W,YUSHIN G.Electrical double layer capacitors with activated sucrose-derived carbon electrodes[J].Carbon,2011,49: 4830-4838.

[12]WANG Q,CAO Q,WANG X Y,et al.A high-capacity carbon prepared from renewable chicken feather biopolymer for supercapaci tors[J].Journal of Power Sources,2013,225:101-107.

[13]LU H L,DAI W J,ZHENG M B,et al.Electrochemical capacitive behaviors of ordered mesoporous carbons with controllable pore sizes[J].Journal of Power Sources,2012,209:243-250.

[14]HE X J,LING P H,YU M X,et al.Rice husk-derived porous carbons with high capacitance by ZnCl2activation for supercapacitors[J].Electrochimica Acta,2013,105:635-641.

[15]HE X J,LI R C,HAN J F,et al.Facile preparation of mesoporous carbonsforsupercapacitors by one-step microwave-assisted ZnCl2activation[J].Materials Letters,2013,94:158-160.

[16]HE X J,LING P H,QIU J S,et al.Efficient preparation of biomass-based mesoporous carbons for supercapacitors with both high energy density and high power density[J].Journal of Power Sources,2013,240:109-113.

[17]DU S H,WANG L Q,FU X T,et al.Hierarchical porous carbon microspheres derived from porous starch for use in high-rate electrochemical double-layer capacitors[J].Bioresour Technol,2013, 139:406-409.

[18]LV Y K,GAN L H,LIU M X,et al.A self-template synthesis of hierarchical porous carbon foams based on banana peel for supercapacitor electrodes[J].J Power Sources,2012,209:152-157.

[19]HUANG W T,ZHANG H,HUANG Y Q,et al.Hierarchical porous carbon obtained from animal bone and evaluation in electric double-layer capacitors[J].Carbon,2011,49:838-843.

[20]CHEN W,ZHANG H,HUANG Y,et al.A fish scale based hierarchical lamellar porous carbon material obtained using a natural template for high performance electrochemical capacitors[J].Mater Chem,2010,20:4773-4775.

[21]LAUREN M C,FERAL T,SALDA?A M D A.Barley beta-glucan aerogels via supercritical CO2drying[J].Food Research International,2012,l48:442-448.

[22]LAUREN M C,FERAL T,SALDA?A M D A.Barley β-glucan aerogels as a carrier for flax oil via supercritical CO2[J].Journal of Food Engineering,2012,111:625-631.

[23]LU Y,SUN Q F,YANG D J,et al.Fabrication of mesoporous lignocellulose aerogels from woodvia cyclic liquid nitrogen freezingthawing in ionic liquid solution[J].Mater Chem,2012,22: 13548-13557.

[24]JUUSO T K,HIEKKATAIPALE P,MALM J,et al.Inorganic hollow nanotube aerogels by atomic layer depositio nonto native nanocellulose templates[J].ACS Nano,2011,5(3):1967-1974.

[25]WU X L,WEN T,GUO H L,et al.Biomass-derived sponge-like carbonace ous hydrogels and aerogels for supercapacitors[J].ACS Nano,2013,7(4):3589-3597.

[26]GRZYB B,HILDENBRAND C,BERTHON-FABRY S,et al.Functionalisation and chemical characterization of cellulose-derived carbon aerogels[J].Carbon,2010,48:2297-2307.

[27]SINGH J,DUTTA P K,DUTTA J,et al.Preparation and properties of highly soluble chitosanl-glutamic acid aerogel derivative [J].Carbohydrate Polymers,2009,76(2):188-195.

[28]TSIOPTSIAS C,MICHAILOF C,STAUROPOULOS G,et al.Chitin and carbon aerogels from chitin alcogels[J].Carbohydrate Polymers,2009,76(4):535-540.

[29]CHANG X H,CHEN D R,JIAO X L.Starchde rived carbon aerogels with high performance for sorption of cationic dyes[J].Polymer,2010,51:3801-3807.

[30]IKOMA T,KOBAYASHI H,TANAKA J,et al.Microstructure, mechanical,and biomimetic properties of fish scales from Pagrus major[J].J Struct Biol,2003,142:327-333.

[31]JIANG L,YAN J W,HAO L X,et al.High rate performance activated carbons prepared from ginkgo shells for electrochemical supercapacitors[J].Carbon,2013,56:146-154.

Application of biomass-based carbon materials for electrochemical double-layer capacitors

By the consuming of chemical energy and deteriorating of environment, even though the electrode of electrochemical double-layer capacitors(EDLC)always consist of carbon materials,the production and application for traditional carbon materials have been challenged.Therefore,using biomass-based materials as precursor to prepare porous carbon has become a hot topic for EDLCs.The preparation and application progress of the biomass-based carbon materials were introduced.The influence of different raw materials and preparation methods on electrochemical properties was reviewed.

electrochemical double-layer capacitors;biomass-based carbon materials;porous carbon materials

TM 53

A

1002-087 X(2016)06-1334-03

2015-12-05

寧波市重大科技專項(2013B6003)

盧穎莉(1986—)，女，陜西省人，碩士研究生，主要研究方向?yàn)槌?jí)電容器的工程化制備與性能研究。

喬志軍，男，E-mail：zjqiao@csrcap.com